vestibИзвестия Национальной академии наук Беларуси. Серия биологических наукProceedings of the National Academy of Sciences of Belarus, Biological Series1029-89402524-230XThe Republican Unitary Enterprise Publishing House "Belaruskaya Navuka"vestib-177Research ArticleСтатьиБиотрансформация бактериями рода Acinetobacter отработанного подсолнечного масла в поверхностно-активные вещества и экзополисахаридыBiotransformation of waste sunflower oil by bacteria genus Acinetobacter in surfactants and exopolysaccharidiesПирогТ. П.PirogT. P.tapirog@nuft.edu.uaПавлюковецИ. В.PavlucovetsI. V.noemail@neicon.ruИвахнюкН. А.IvahniukN. A.noemail@neicon.ruСавенкоИ. В.SavenkoI. V.noemail@neicon.ruНациональный университет пищевых технологийNational University of Food Technologies20150706201604116121Copyright © Пирог Т.П., Павлюковец И.В., Ивахнюк Н.А., Савенко И.В., 20162016Пирог Т.П., Павлюковец И.В., Ивахнюк Н.А., Савенко И.В.Pirog T.P., Pavlucovets I.V., Ivahniuk N.A., Savenko I.V.Данная работа распространяется под лицензией Creative Commons Attribution 4.0.This work is licensed under a Creative Commons Attribution 4.0 License.https://vestibio.belnauka.by/jour/article/view/177

Установлена возможность замены рафинированного подсолнечного масла для синтеза поверхностно-активных веществ Acmetobacter calcoaceticus ІМВ B-7241 и экзополисахаридов Acinetobacter sp. ІМВ В-7005 на дешевые и доступные субстраты (нерафинированное, отработанное после жарки картофеля и мяса масло). При использовании инокулята, выращенного на рафинированном масле, количество синтезированных на отработанном подсолнечном масле поверхностно-активных веществ и экзополисахаридов было выше, чем на очищенном (рафинированном) субстрате.

The possibility of refined sunflower oil replacing for surfactants and exopolysaccharides synthesis by Acmetobacter calcoaceticus IMV B-7241 and Acinetobacter sp. ІМВ В-7005, on cheaper and affordable substrates (unrefined, waste after frying potato and meat oil) was shown. The quantity of synthesized surfactants and exopolysaccharides on waste sunflower oil was higher than on purified (refined) substrate with using inoculum grown on refined oil.

Acmetobacter calcoaceticus ІМВ B-7241Acinetobacter sp. ІМВ В-7005поверхностно-активные веществаэкзополисахаридыотработанное подсолнечное маслобиосинтезAcmetobacter calcoaceticus ІМВ B-7241Acinetobacter sp. ІМВ В-7005surfactantsexopolysaccharidieswaste sunflower oilbiosynthesisReferencesFermentation technologies for the optimization of marine microbial exopolysaccharide production / I. Finoreet [et al.] // Mar. Drugs. - 2014. - Vol. 12, N 5. - P. 3005-3024. - doi: 10.3390/md12053005.Fermentation technologies for the optimization of marine microbial exopolysaccharide production / I. Finoreet [et al.] // Mar. Drugs. - 2014. - Vol. 12, N 5. - P. 3005-3024. - doi: 10.3390/md12053005.Exopolysaccharides and antimicrobial biosurfactants produced by Paenibacillus macerans TKU029 / T. W. Liang [et al.] // Appl. Biochem. Biotechnol. - 2014. - Vol. 172, N 2. - P. 933-950.Exopolysaccharides and antimicrobial biosurfactants produced by Paenibacillus macerans TKU029 / T. W. Liang [et al.] // Appl. Biochem. Biotechnol. - 2014. - Vol. 172, N 2. - P. 933-950.Surfactants tailored by the class Actinobacteria / J. H. Kugler [et al.] // Front. Microbiol. - 2015. - Vol. 6. - doi: 10.3389/ fmicb.2015.00212.Surfactants tailored by the class Actinobacteria / J. H. Kugler [et al.] // Front. Microbiol. - 2015. - Vol. 6. - doi: 10.3389/ fmicb.2015.00212.Подгорский, В. С. Интенсификация технологий микробного синтеза / В. С. Подгорский, Г. О. Иутинская, Т. П. Пирог. - К.: Наук. думка, 2010. - 327 с.Подгорский, В. С. Интенсификация технологий микробного синтеза / В. С. Подгорский, Г. О. Иутинская, Т. П. Пирог. - К.: Наук. думка, 2010. - 327 с.Biodiesel production from waste cooking oil using sulfuric acid and microwave irradiation processes / P. D. Patil [et al.] // J. Environ. Protection. - 2012. - Vol. 3. - P. 107-113. - doi.org/10.4236/jep.2012.31013.Biodiesel production from waste cooking oil using sulfuric acid and microwave irradiation processes / P. D. Patil [et al.] // J. Environ. Protection. - 2012. - Vol. 3. - P. 107-113. - doi.org/10.4236/jep.2012.31013.Bhardwaj, G. Utilization of oleo-chemical industry by-products for biosurfactant production / G. Bhardwaj, S. S. Cameotra, H. K. Chopra // AMB Express. - 2013. - Vol. 3. - doi: 10.1186/2191-0855-3-68.Bhardwaj, G. Utilization of oleo-chemical industry by-products for biosurfactant production / G. Bhardwaj, S. S. Cameotra, H. K. Chopra // AMB Express. - 2013. - Vol. 3. - doi: 10.1186/2191-0855-3-68.Cost effective technologies and renewable substrates for biosurfactants’ production / I. M. Banat [et al.] // Front. Microbiol. - 2014. - Vol. 5. - doi: 10.3389/fmicb.2014.00697.Cost effective technologies and renewable substrates for biosurfactants’ production / I. M. Banat [et al.] // Front. Microbiol. - 2014. - Vol. 5. - doi: 10.3389/fmicb.2014.00697.The influence of conditions of Acinetobacter calcoaceticus K-4 strain cultivation on surface-active substances synthesis / T. P. Pirog [et al.] // Appl. Biochem. Microbiol. - 2009. - Vol. 45, N 3. - P. 272-278.The influence of conditions of Acinetobacter calcoaceticus K-4 strain cultivation on surface-active substances synthesis / T. P. Pirog [et al.] // Appl. Biochem. Microbiol. - 2009. - Vol. 45, N 3. - P. 272-278.Raza, Z. A. Evaluation of distant carbon sources in biosurfactant production by a gamma ray-induced Pseudomonas putida mutant / Z. A. Raza, M. S. Khan, Z. M. Khalid // Proc. Biochem. - 2007. - Vol. 42, N 4. - P. 686-692.Raza, Z. A. Evaluation of distant carbon sources in biosurfactant production by a gamma ray-induced Pseudomonas putida mutant / Z. A. Raza, M. S. Khan, Z. M. Khalid // Proc. Biochem. - 2007. - Vol. 42, N 4. - P. 686-692.Williams, A. G. Exopolysaccharide production by Pseudomonas NCIB 11264 grown in continuous culture / A. G. Williams, W. T. Wimpenny // J. Gen. Microbiol. - 1978. - Vol. 104, N 1. - P. 47-57.Williams, A. G. Exopolysaccharide production by Pseudomonas NCIB 11264 grown in continuous culture / A. G. Williams, W. T. Wimpenny // J. Gen. Microbiol. - 1978. - Vol. 104, N 1. - P. 47-57.Ivahniuk, M. O. Intensification of microbial exopolysaccharide ethapolan synthesis under Acinetobacter sp. IMV B-7005 cultivation on sunflower oil / M. O. Ivahniuk, T. P. Pirog // Ukr. Food J. - 2014. - Vol. 3, N 2. - P. 257-262.Ivahniuk, M. O. Intensification of microbial exopolysaccharide ethapolan synthesis under Acinetobacter sp. IMV B-7005 cultivation on sunflower oil / M. O. Ivahniuk, T. P. Pirog // Ukr. Food J. - 2014. - Vol. 3, N 2. - P. 257-262.Production of a new exopolysaccharide (EPS) by Pseudomonas oleovorans NRRL B-14682 grown on glycerol / F. Freitas [et al.] // Proc. Biochem. - 2010. - Vol. 45, N 3. - P. 297-305.Production of a new exopolysaccharide (EPS) by Pseudomonas oleovorans NRRL B-14682 grown on glycerol / F. Freitas [et al.] // Proc. Biochem. - 2010. - Vol. 45, N 3. - P. 297-305.Kang, Y. S. Protection against diesel oil toxicity by sodium chloride-induced exopolysaccharides in Acinetobacter sp. strain DR1 / Y. S. Kang, W. Park // J. Biosci. Bioeng. - 2010. - Vol. 109, N 2. - P. 118-123.Kang, Y. S. Protection against diesel oil toxicity by sodium chloride-induced exopolysaccharides in Acinetobacter sp. strain DR1 / Y. S. Kang, W. Park // J. Biosci. Bioeng. - 2010. - Vol. 109, N 2. - P. 118-123.Schmid, J. Scleroglucan: biosynthesis, production and application of a versatile hydrocolloid / J. Schmid, V. Meyer, V. Sieber // Appl. Microbiol. Biotechnol. - 2011. - Vol. 91, N 4. - P. 937-947.Schmid, J. Scleroglucan: biosynthesis, production and application of a versatile hydrocolloid / J. Schmid, V. Meyer, V. Sieber // Appl. Microbiol. Biotechnol. - 2011. - Vol. 91, N 4. - P. 937-947.Oner, E. T. Microbial production of extracellular polysaccharides from biomass. In: Pretreatment techniques for biofuels and biorefineries / E. T. Oner; cd. Z. Fang. Springer-Verlag Berlin Heidelberg, 2013. - 457 p.Oner, E. T. Microbial production of extracellular polysaccharides from biomass. In: Pretreatment techniques for biofuels and biorefineries / E. T. Oner; cd. Z. Fang. Springer-Verlag Berlin Heidelberg, 2013. - 457 p.Arli, S. D. Curdlanlike exopolysaccharide production by Cellulomonas flavigena UNP3 during growth on hydrocarbon substrates / S. D. Arli, U. B. Trivedi, K. C. Patel // World J. Microbiol. Biotechnol. - 2011. - Vol. 27, N 6. - P. 1415-1422.Arli, S. D. Curdlanlike exopolysaccharide production by Cellulomonas flavigena UNP3 during growth on hydrocarbon substrates / S. D. Arli, U. B. Trivedi, K. C. Patel // World J. Microbiol. Biotechnol. - 2011. - Vol. 27, N 6. - P. 1415-1422.Павлюковец, И. Биоконверсия подсолнечного масла в поверхностно-активные вещества Nocardia vaccinii ІМВ В-7405 и Acinetobacter calcoaceticus IMB B-7241 / И. Павлюковец [и др.] // Пищевая промышленность. - 2014. -№ 16. - С. 23-27.Павлюковец, И. Биоконверсия подсолнечного масла в поверхностно-активные вещества Nocardia vaccinii ІМВ В-7405 и Acinetobacter calcoaceticus IMB B-7241 / И. Павлюковец [и др.] // Пищевая промышленность. - 2014. -№ 16. - С. 23-27.Govindammal, M. Production and characterization of biosurfactant using renewable substrates by Pseudomonas fluorescence isolated from mangrove ecosystem / M. Govindammal, R. Parthasarathi // J. Appl. Chem. - 2013. - Vol. 2, N 1. -P. 55-62.Govindammal, M. Production and characterization of biosurfactant using renewable substrates by Pseudomonas fluorescence isolated from mangrove ecosystem / M. Govindammal, R. Parthasarathi // J. Appl. Chem. - 2013. - Vol. 2, N 1. -P. 55-62.Saravanan, V. Production of biosurfactant by Pseudomonas aeruginosa PB3A using agro-industrial wastes as a carbon source / V. Saravanan, V. Subramaniyan // Malays. J. Microbiol. - 2014. - Vol. 10, N 1. - P. 57-62.Saravanan, V. Production of biosurfactant by Pseudomonas aeruginosa PB3A using agro-industrial wastes as a carbon source / V. Saravanan, V. Subramaniyan // Malays. J. Microbiol. - 2014. - Vol. 10, N 1. - P. 57-62.

The authors declare that there are no conflicts of interest present.